2020 Jayco Melbourne Recalls

The defect

Jayco, Inc. (Jayco) is recalling certain 2020-2021 Entegra Launch, Qwest, Jayco Melbourne, and Melbourne Prestige motorhomes. The heating, ventilation, and air conditioning (HVAC) blower motor circuit may be inadequate, which can allow the wiring harness to overheat.

The risk

A wiring harness that overheats increases the risk of a fire.

The fix

Owners are advised to only operate the HVAC front blower in manual (not automatic) mode whenever the engine is on. Do not use the maximum blower or lowest/highest temperature settings until the remedy is performed. Dealers will relocate and replace the fuse and wiring harness, free of charge. Owner notification letters are expected to be mailed August 18, 2023. Owners may contact Jayco customer service at 1-800-283-8267.

The defect

Jayco, Inc. (Jayco) is recalling certain 2019-2023 Entegra Launch, Launch LE, Qwest, Jayco Melbourne, Melbourne Prestige, Terrain, and Terrain LE motorhomes. The guide bushing on the parking pawl may fatigue, which can cause the parking pawl not to engage and result in a vehicle rollaway.

The risk

Vehicle rollaway increases the risk of a crash.

The fix

Dealers will update the software of the electronic stability, transmission control, direct select module, and electronic ignition switch control units, free of charge. Owner notification letters were mailed March 8, 2023. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is MB 22V-796.

The defect

Jayco, Inc. (Jayco) is recalling certain 2020-2021 Melbourne and Melbourne Prestige motorhomes. The instrument cluster may fail to display any information when the vehicle is started.

The risk

A blank instrument panel will not show critical information, such as vehicle speed, fuel gauge, warning messages, and warning lights, increasing the risk of a crash.

The fix

Dealers will update the instrument cluster software on the affected vehicles, free of charge. Owner notification letters were mailed June 15, 2023. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is Daimler 23V-204.

Reported January 6, 2023 by Jayco, Inc.

The defect

Jayco, Inc. (Jayco) is recalling certain 2020-2021 Jayco Melbourne, Melbourne Prestige and Entegra Qwest motorhomes built on Sprinter chassis and equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.

The risk

If the wiring harness is damaged, the side air bag within the seat may deploy unexpectedly or not deploy as designed in the event of a crash, increasing the risk of injury to vehicle occupants.

The fix

Jayco will notify owners, and Mercedes-Benz Sprinter dealers will inspect the wire harness routing for both front seats and will repair the wiring and add clips or cable ties as needed, free of charge. The recall began August 21, 2020. Owners may contact Jayco customer service at 1-800-517-9137.

Reported October 8, 2020 by Jayco, Inc.

The defect

Jayco, Inc. (Jayco) is recalling certain 2020 Motorized Alante, Greyhawk, Melbourne, Precept, Redhawk, Seneca, Accolade, Emblem, Esteem, Odyssey, Qwest, and Vision recreational vehicles. The adhesive bond between the glass and the metal hinge frame of the frameless crank out vent and egress windows may fail which would then allow the glass to detach and fall out.

The risk

If the window glass detaches while the vehicle is moving it could become a projectile, increasing the risk of injury or a crash.

The fix

Jayco will notify owners, and dealers will inspect the frameless windows for proper adhesive bond strength, replacing the windows as necessary, free of charge. This recall began June 15, 2020. Owners may contact Jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901508.

Reported September 6, 2020 by Jayco, Inc.

The defect

Jayco, Inc. (Jayco) is recalling certain 2019-2020 Entegra Qwest and 2019-2021 Jayco Melbourne and Melbourne Prestige Class C motorhomes built on Mercedes-Benz Sprinter chassis. The Operator's Manual may not contain the correct information about how the automatic parking function ("Auto-P") operates.

The risk

If the driver relies on the Auto-P function as described in the Operator's Manual, vehicle rollaway or movement may occur, increasing the risk of a crash.

The fix

Jayco will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will provide the correct description of the Auto-P function for the Operator's Manual, free of charge. This recall began May 19, 2020. Owners may contact Jayco customer service at 1-800-517-9137 or Sprinter service at 1-877-762-8267. The booklet with correct information is also available online, free of charge.

Reported May 6, 2020 by Jayco, Inc.

The defect

Jayco, Inc. (Jayco) is recalling certain 2019-2021 Entegra Qwest and Jayco Melbourne and Melbourne Prestige motorhomes built on Mercedes-Benz Sprinter chassis. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.

The risk

Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.

The fix

Jayco will notify owners, and Mercedes Sprinter dealers will inspect and replace the brake hoses, and the fender liners will be modified, free of charge. The recall began July 14, 2020. Owners may contact Jayco customer service at 1-800-517-9137.

Reported February 7, 2020 by Jayco, Inc.