NHTSA Safety Recalls
2002 Mazda Mpv Recalls
The 2002 Mazda Mpv has 4 NHTSA safety recalls on file. Recall repairs are always free, whatever the car's age or mileage.
A recall covers a range of VINs, not every Mazda Mpv built. Check your own 17-character VIN before assuming yours is affected.
4 recalls on the 2002 Mazda Mpv
EQUIPMENT:OTHER:LABELS
NHTSA 02V078000- The defect
- CERTAIN MINI VANS FAIL TO COMPLY TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." AN INCORRECT GROSS AXLE WEIGHT RATING (GAWR) WAS INDICATED ON THE CERTIFICATION LABEL.
- The fix
- OWNERS WILL BE MAILED ACCURATE CERTIFICATION LABELS AND INSERTS FOR THE OWNER'S MANUAL. OWNER NOTIFICATION BEGAN JUNE 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MAZDA AT 1-800-222-5500.
VEHICLE SPEED CONTROL:CABLES
NHTSA 04V234000- The defect
- ON CERTAIN MINIVANS EQUIPPED WITH CRUISE CONTROL, THE CRUISE CONTROL ACTUATOR CABLE MAY BE BROKEN DUE TO INSUFFICIENT STRENGTH (GROUP 1). ALSO INCLUDED ARE CERTAIN 2000-2001 MINIVANS EQUIPPED WITH CRUISE CONTROL BUILT BETWEEN MARCH 31, 1999 AND MARCH 31, 2001, THAT HAVE HAD THE CRUISE CONTROL REPAIRED AND POSSIBLY HAD A DEFECTIVE CABLE INSTALLED DURING THAT REPAIR (GROUP 2).
- The risk
- IT IS POSSIBLE THAT THE BROKEN ACTUATOR CABLE MAY BE OUT OF POSITION AND COULD INTERFERE WITH THE OPERATION OF THE ACCELERATOR CABLE, PREVENTING A DECREASE IN ENGINE SPEED WHILE DRIVING, INCREASING THE RISK OF A CRASH.
- The fix
- DEALERS WILL REPLACE THE ACTUATOR CABLE. OWNER NOTIFICATION FOR VEHICLES INVOLVED IN GROUP 1 BEGAN ON JULY 7, 2004. OWNER NOTIFICATION FOR VEHICLES INVOLVED IN GROUP 2 BEGAN ON SEPTEMBER 10, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
EXTERIOR LIGHTING:FOG LIGHTS
NHTSA 03V053000- The defect
- ON CERTAIN MINI VANS EQUIPPED WITH FRONT FOG LIGHTS,THE FOG LIGHT BULB SOCKET MAY HAVE BEEN INSTALLED IMPROPERLY.
- The risk
- IF THE VEHICLE CONTINUES TO BE USED WITH THIS CONDITION, THE BULB SOCKET AND THE WIRING HARNESS MAY SEPARATE FROM THE FOG LIGHT HOUSING IF EXPOSED TO SHOCK AND/OR VIBRATION AND DROP INSIDE THE BUMPER. SHOULD THIS OCCUR, THE OPERATION OF THE FOG LIGHT MAY THEN CAUSE THE BUMPER TO BURN.
- The fix
- DEALERS WILL INSPECT THE INSTALLATION CONDITION OF THE FOG LIGHT BULB ASSEMBLY, AND REPAIR IT WHEN NECESSARY. OWNER NOTIFICATION BEGAN MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MAZDA AT 1-800-222-5500.
EXTERIOR LIGHTING:FOG LIGHTS
NHTSA 03V206000- The defect
- ON CERTAIN MINI VANS AND PASSENGER VEHICLES, THE SOCKET HOLDER IN THE FOG LIGHTS IS INSTALLED IN THE LAMP CASING USING PRESSURE. DURING OPERATION OF THE FOG LIGHT, THE HEAT FROM THE BULB CAN EXPAND THE SOCKET HOLDER. THE EXPANSION CAN FORCE THE SOCKET HOLDER REARWARD. AFTER REPEATEDLY BEING SUBJECT TO THIS EXPANSION, IF THE FOG LIGHT IS ALSO SUBJECTED TO VIBRATION DURING VEHICLE OPERATION, THE SOCKET HOLDER WITH THE BULB HOLDER AND THE WIRING HARNESS MAY SEPARATE FROM THE FOG LIGHT CASING.
- The risk
- SHOULD THIS OCCUR, THE BULB SOCKET AND THE HARNESS CAN DROP INSIDE THE BUMPER AND POSSIBLY BUT RARELY, THE HEAT GENERATED BY THE BULB CAN CAUSE THE BUMPER TO BURN.
- The fix
- DEALERS WILL INSTALL A SPRING TO PREVENT THE SOCKET HOLDER FROM SEPARATING FROM THE LAMP CASE. OWNER NOTIFICATION BEGAN ON JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MAZDA AT 1-800-222-5500.
Reported May 6, 2003 by MAZDA NORTH AMERICAN OPERATIONS
Checking your own car
A recall applies to a range of VINs, not to every 2002 Mazda Mpv built. To confirm whether yours is affected, find the 17-character VIN on the driver-side dashboard or door jamb and enter it in NHTSA's official lookup.
Repairs for safety recalls are free and never expire. A dealer cannot charge you, and cannot refuse on the grounds that the car is old or out of warranty. If one does, call the NHTSA hotline on 1-888-327-4236.