2001 Subaru Legacy Recalls

The defect

CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS WERE PRODUCED WITH AN IMPROPERLY MANUFACTURED TRANSMISSION PARKING ROD. WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE "P" (PARK) POSITION, THE TRANSMISSION PARK MECHANISM, THAT IS INTENDED TO HOLD YOUR VEHICLE, MAY NOT ENGAGE.

The risk

THE VEHICLE COULD THEN MOVE/ROLL WITHOUT PRIOR WARNING, INCREASING THE RISK OF A CRASH.

The fix

DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION PARKING ROD ASSEMBLY. OWNER NOTIFICATION JANUARY 8, 2003. AN INTERIM OWNER NOTIFICATION WILL BE SENT DURING NOVEMBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

The defect

Airtex Products LP (Airtex) is recalling certain model E8598M, E8518M, E8600M, E8596M, and E8597M fuel pumps manufactured July 26, 2013, and July 29, 2013 and used as aftermarket replacements on Subaru Baja's, Outback's and Legacy's. The affected fuel pumps were sold or installed into the aftermarket applications on or after July 26, 2013, and may may leak fuel from the base of a fuel line connection when the gas tank is full.

The risk

A fuel leak in the presence of an ignition source increases the risk of a fire.

The fix

Airtex will notify owners, and will replace the fuel pump, free of charge. Recall is expected to begin on January 2, 2014. Customers may contact Airtex at 1-800-880-3056. The recall is expected to begin during January 2014. This recall is being conducted by Airtex, not by Subaru.

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES. POSSIBLE FUEL LEAKAGE OF UNDER-HOOD FUEL HOSES AT LOW AMBIENT TEMPERATURES (-40 DEGREES C) ONCE THE FUEL HOSES AGE AND BECOME LESS FLEXIBLE.

The risk

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

The fix

DEALERS WILL INSPECT FOR UNDER-HOOD FUEL HOSES WITH LOT NUMBERS 0804 AND 0806 AND ALL FUEL HOSES WITH THOSE NUMBERS WILL BE REPLACED.

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES. INCORRECT BEIGE REAR CENTER SEAT BELT WEBBING WAS INSTALLED. THE BELT LENGTH IS TOO SHORT.

The risk

THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED IN THE EVENT OF A CRASH.

The fix

DEALERS WILL REPLACE ALL BEIGE COLORED REAR CENTER LAP/SHOULDER BELTS WITH LOT NUMBER 0171.

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES. A CASTING FLAW IN THE RIGHT FRONT BEARING HOUSING COULD RESULT IN LOSS OF STEERING IF THE CASTING FLAW SHOULD EXIST IN THE TIE-ROD ARM.

The risk

THIS CASTING FLAW COULD CAUSE GREASE LEAKAGE, FRONT WHEEL BEARING FAILURE DUE TO LOSS OF GREASE, OR LOSS OF STEERING DUE TO TIE-ROD END SEPARATION.

The fix

DEALERS WILL REPLACE ALL FRONT BEARING HOUSINGS WITH A LOT NUMBER OF OF15.

The defect

ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AND WILL REMAIN IN AN OPEN POSITION.

The risk

IF THIS OCCURS DURING VEHICLE OPERATION, THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.

The fix

DEALERS WILL INSTALL A CRUISE CONTROL CABLE RETAINING CLIP TO THE CRUISE CONTROL LEVER TAB ON THE THROTTLE SHAFT IN ORDER TO PREVENT THE CRUISE CONTROL CABLE FROM COMING OUT OF ITS TRACK. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.

The defect

THIS RECALL APPLIES TO CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. CERTAIN REAR SUSPENSION SUBFRAME COMPONENTS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE ROAD SALTS FOR A PERIOD OF SEVERAL YEARS, COULD RESULT IN RUST-OUT OF THE COMPONENT AND POSSIBLE BREAKAGE OF THE SUBFRAME.

The risk

IF SUCH BREAKAGE OCCURS WHILE THE VEHICLE IS BEING OPERATED, CONTROL OF THE VEHICLE COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.

The fix

DEALERS WILL CLEAN AND RUST-PROOF THE REAR SUSPENSION SUBFRAME. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUALLY-ADJUSTABLE (NON-POWERED) SEATS. CERTAIN INNER FRONT SLIDE RAIL LATCH MECHANISMS MAY HAVE BEEN IMPROPERLY WELDED.

The risk

IF AN INNER SLIDE RAIL LATCH MECHANISM BREAKS DUE TO IMPROPER WELDING, FORWARD AND REARWARD SEAT ADJUSTMENT WILL NO LONGER BE POSSIBLE. IN THE EVENT OF A CRASH, THE SLIDE RAILS COULD BREAK, EXPOSING THE OCCUPANT TO A RISK OF INJURY.

The fix

DEALERS WILL REPLACE ONE OR BOTH FRONT SEAT INNER SLIDE RAILS. OWNER NOTIFICATION BEGAN MARCH 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Reported July 2, 2001 by SUBARU OF AMERICA, INC.