2000 Chevrolet Lumina Recalls

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE RIGHT FRONT BRAKE HOSE IS INCORRECTLY ROUTED BEHIND THE BRAKE PIPE BRACKET RESTRICTING BRAKE HOSE MOVEMENT THAT COULD CAUSE THE HOSE TO EITHER BE CUT BY THE BRACKET OR SEPARATED AT THE CALIPER.

The risk

IF THE HOSE BECOMES DISCONNECTED OR DAMAGED, THERE CAN BE A LOSS OF PRESSURE IN ONE HALF OF THE BRAKE SYSTEM. THE BRAKE WARNING LAMP MAY BE ON, THE PEDAL WILL BE LOWER THAN NORMAL, AND STOPPING DISTANCES WILL BE LONGER, INCREASING THE RISK OF A CRASH.

The fix

DEALERS WILL REPLACE AND CORRECTLY ROUTE THE RIGHT FRONT BRAKE HOSE ASSEMBLY.

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE CLAMP THAT SECURES THE FLEXIBLE FUEL FILL HOSE TO THE METAL FILL TUBE MAY BE LOOSE AND COULD SEPARATE.

The risk

THIS COULD CAUSE FUEL LEAKAGE EXCEEDING THE PERMISSIBLE AMOUNT.

The fix

DEALERS WILL INSPECT THE FUEL HOSE FILL NECK CLAMP AND, IF NECESSARY, REPOSITION AND TIGHTEN THE CLAMP.

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE PASSENGER SIDE AIR BAG MODULES HAVE AN UNDERSIZED INFLATOR ORIFICE.

The risk

IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER SIDE AIR BAG DEPLOYMENT, THIS UNDERSIZED ORIFICE CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF AN AIR BAG INFLATOR MODULE EXPLODES, METAL AND/OR PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO THE VEHICLE OCCUPANT.

The fix

DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG MODULES.

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH REAR DRUM BRAKES. THE BOLT HEAD(S) ON THE REAR SPINDLE ROD CAN SEPARATE.

The risk

THE REAR WHEEL CAN SHIFT, CAUSING REAR STEERING OF THE VEHICLE. THE DRIVER COULD LOSE CONTROL AND A CRASH COULD OCCUR.

The fix

DEALERS WILL REPLACE THE REAR SPINDLE BOLTS.

The defect

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

The risk

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

The fix

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Reported December 3, 2007 by DELPHI

The defect

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

The risk

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

The fix

DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

Reported July 8, 2000 by GENERAL MOTORS CORP.